Your Cart
Your cart is empty.
Browse the store →Your cart is empty.
Browse the store →
Water is more than an H2O equation. Putting aside a host of many other impurities that may be found in your consumption water supply; there are essential dissolved minerals in your water that are critical for biological functions for you, plants, and other biological lifeforms. Removing these mineral from your water (i.e. calcium, magnesium) will start to alter your water chemistry and eventually jeopardize your health.
The Vulcan Electronic Anti-Scale System is NOT a water filter; it does NOT remove minerals, it temporarily changes (1-7 days) the molecular construction of minerals so they do not bond to surfaces. All the benefits of softened water but without the environmental influence, that slimy feel of soft water, and without using salt or other consumables.
Cooling Towers
Boilers
Hot Water Tanks
Heat Exchangers
Chillers
Water Pressure
Pressure Valves
Circulating Pumps
Water Softeners
Swimming Pools
Irrigation Systems
Water Filters
Restroom Facilities
Showering Facilities
Grease Traps
Ice Machines
Heavy industry relies on Vulcan for critical infrastructure protection
±800kV UHV CONVERTER STATION
The Vulcan mineral descaling system was incorporated into the equipment design for its low power, zero chemical dosing, no maintenance, eco-friendly and safety benefits to support the cooling circulating water system of UHV converter equipment.
See how Vulcan performs in demanding industrial environments
🏭 CEMENT
"Saved almost $400,000 using the Vulcan descaling technology instead of using a chemical system."
Holcim Cement
Global Cement Leader
⚡ POWER GENERATION
"The Vulcan anti-scale solution was installed to solve serious scaling problems in the power plant's cooling towers."
Huaneng Power
Power Generation
⛏️ MINING
"Vulcan S350 installed in explosion-proof box 600 meters underground to solve scaling and corrosion in drainage system."
Tangshan Kailuan
Coal Mining
Vulcan has been descaling large scale equipment for decades
Installation is very easy but if you need onsite installation support, reach out to us.
Put the two cable ties through the fixing holes at the bottom of the electronic device. Place the device onto the pipe. Use the cable ties to secure the device to the pipe.
Connect one of the impulse bands to the device and use another cable tie to fasten it onto the pipe.
Wind the impulse bands around the pipe producing a coil. Make sure you wind the band tightly to the pipe and place the windings close to each other.
Latch the end of the impulse band to the pipe using another cable tie. Now repeat the procedure with the second impulse band.
First plug the connector into the upper right in-jack of the device and then connect the power supply unit with an electrical outlet.
The red pilot lights will illuminate as soon as the device starts to operate. Vulcan works from now on and maintenance-free.
Protect the electronic unit, the impulse bands and the power supply against humidity and water.
Only use the provided electronic switching adaptor.
Do not cut the impulse bands or the 36 V power cord of the power supply unit.
Do not remove the end caps or the impulse band insulation.
The operating temperature of Vulcan ranges from -13°F to 122°F.
Temperature peaks on heating element surfaces should not exceed ~203°F.
Clean the device with water only.
For optimal water treatment, Vulcan is best installed near the water meter or at the main water supply.
The impulse band windings can be placed on the left side, on the right side or underneath the electronic device. Leave a safe distance of 1 inch or more between the bands.
Vulcan can be installed vertically, horizontally or at any other angle. If there is no space available on the pipe the electronic block can also be wall-mounted.
In case of limited space the windings can be placed partly on the main pipe and partly on the distributor pipe.
These various installations setups are possible because the treatment impulses extend over 9-16 feet on either sides of the impulse bands along the water pipe length.
PROTECT AND CLEAN COOLING TOWERS
Chemically treating cooling towers to remove mineral scale does not make a lot of financial sense since as little as 1 mm of scale has been linked to an increase of 15% in energy demands. If you use the Vulcan hard water mineral descaler it will continuously remove and prevent mineral scale from forming without requiring labor, resins, filtration or any other consumables (other than 2.5 watts of energy)
PROTECT INDUSTRIAL BOILERS FROM RAPID MINERAL DEPOSITS
From small single use hot water tanks to enormous industrial boilers, the Vulcan descaler has a proven success rate from over 70 countries at preventing and removing mineral scale in all type of equipment. This greentech not only improves energy efficiency but also increases equipment longevity and reduces maintenance labor costs while supporting sustainability interests.
CLEAN HEAT EXCHANGERS WITHOUT DISMANTLING
⅛ inch thickness on heating elements can result in 20%-25% efficiency loss. It is completely unrealistic to pull apart your buildings heat exchangers every day and manually clean surfaces. Incorporating the Vulcan descaling tech into your building will mean that every second that water is flowing through pipelines and into equipment, surfaces are constantly being cleaned and scale formation prevented.
KEEP INDUSTRIAL CHILLERS OPERATING AT PEAK EFFICIENCY
Speak to facility maintenance companies or a building's maintenance staff and scale deposits are a constant bane on equipment maintenance. It is common knowledge that scaling/ limescale fouling increases energy costs by reducing the heat transfer surface on both cooling (chiller) and heating (boiler) systems. You could continue to use harmful chemical treatment or outrageously priced water softening systems (that kinda work) or install the Vulcan descaler that constantly work with zero effort.
FULL BUILDING PROTECTION
As water comes into your building to the furthers end point, the Vulcan technology can be positioned in strategic locations to support your family run restaurant, tropical resort location, to industrial manufacturing facility. Contact us and we'll working with you and your building personnel to recommend installation models and locations:
412-848-5058 | Support@VulcanDescaler.com
EXTEND WATER PUMP LIFESPANS
Keep water moving without causing excessing wear-and-tear on pumping equipment. Progressive nations around the world (example: United Arab Emirates) who need to maximize water efficiency have incorporated this environmental tech to prevent and remove mineral scale and rust while increasing the efficiency of the water irrigation equipment.
Waslix gathers, organizes, and researches a massive range of products across water, light, air, and energy. We demystify complex technologies to simplify your high-involvement purchasing decisions, making complete solutions easily accessible.
Edit this HTML block.